"spaceflight is risky business" explains the tweet. i mean, yes, space is a hostile environment, but so is nasa.
i think about how the apollo 1 astronauts sent a picture to their boss' boss, of them praying towards the capsule, a few months before they burned to death in a test.
during the investigation, one senator said NASA had an "evasiveness, ... lack of candor, ... patronizing attitude toward Congress ... refusal to respond fully and forthrightly to legitimate Congressional inquiries"
i also think about the challenger disaster. the one where the rocket contractor went "don't fly" and nasa went "are you suuuuuuuuuuure?" and the contractor went "shrug."
i think about how the investigation only found out the truth because someone leaked the reports to the commission—who then protected their sources by inviting feynman over for dinner, and theatrically working on their car and talking about o-rings, so he'd have an excuse to start looking.
"The commission concluded that the safety culture and management structure at NASA were insufficient to properly report, analyze, and prevent flight issues."
or columbia, where the the management cancelled attempts to look for debris, because it would ruin the schedule.
"the board determined that NASA lacked the appropriate communication and integration channels to allow problems to be discussed and effectively routed and addressed."
the thing that gets me, apart from nasa killing astronauts every twenty years, is that so many people see it as an acceptable cost of progress. if anything, they see it proving the difficulty and the merit of spaceflight.
i'll give you two guesses for how the people who make "self driving cars" think
- while building the Apollo 13 service module, one of the frames that the oxygen tanks were mounted on was dropped a couple inches from a crane, causing a drain tube to get misaligned.
- much of the service module hardware (basically anything that needed to run on the ground) had been redesigned to tolerate 65 volts DC power from the pad during the Gemini program, to allow NASA to cycle vehicles on the pad faster.
- the fail-safe switches that shut off the oxygen tank heaters if the tank got above 80°F were not among this hardware, and were only rated for 28 volts DC.
- during preflight testing, the oxygen tanks needed to be loaded and drained several times.
- when they were attempting to detank the oxygen preflight, they noticed that one of the tanks wouldn't drain through the drain tube, and decided to boil the oxygen off instead of draining it in order to prevent delaying the mission by a month.1
- the pad power going through the heater caused the shut-off switches to fail short, but the good news is that they were redundantly measuring the temperature of the heater on the pad so they could avoid causing permanent damage to the heater circuitry!
- the bad news is that the thermometer on the pad pegged at 85°F, so the heater was, unbeknownst to everyone, getting hot enough to burn off all the insulation from the wires to the tank stir fans and staying there for several hours. these wires sparked 180,000 miles from earth and resulted in the crew having to ration water and electricity for the next week.
the story everyone remembers about Apollo 13 is that human ingenuity saved three people's lives, but the more interesting story to me has always been the mix of cost-cutting, tight deadlines, groupthink, and design failures that endangered them in the first place.
-
the report notes that the crew had signed off on this detanking procedure but even aside from the fact that nobody (least of all them, who were probably spending much of their time getting ready to fly to the moon instead of thinking about engineering details) had the full information at the time, can you imagine the pressure on the astronauts not to be the ones who stopped the line for a month?
